So I've looked around not haven't found anything similar on our forums, therefore I decided to do a quick write up.
Car: 2013 FRS
Odometer reading: 2200 km
Transmission: Automatic
Issue:
Engine knock sound in the range of 2000-3000 RPM in 3rd/4th gears (loudest points) when engine is warm.
The AC was off at all times.
No check engine light at all.
This issue is most evident when the car is in DRIVE (i do not know why, but its not as pronounced when using paddle shifters) and it is in 3rd or 4th gear in the range of 2000-3000 RPM, most evident at 2500 RPM.
To replicate the issue I usually go onto a slightly sloped road and get the car to aforementioned gear/rpm ratio.
The noise is definitely a knocking sound. If i hold it in that gear/RPM it just keeps knocking away.
This issue first arose at about 700-1000 KM. I had just fueled up at Shell (93 octane) gas station and went on the road. It was so bad that I could hear it over music playing. At the time I thought it was a bad batch of gas. I drove for about 50km and after I got home and let the car sit for 10 minutes and started it again the sound wasn't there.
This happened again 2nd time at about 2000 KM. This time I had different fuel (costco 91 octane) and I've went about 450 km on the duel (was 3/4 empty). Therefore I figured that the fuel is not the issue.
I decided to take it to the dealer today and i managed to replicate the issue on a small scale (the knocking wasn't at it's loudest) but the mechanic agreed that there was an issue. They have ordered new high pressure fuel pump for me and will install it in a week.
On the drive back it started knocking pretty loud again.
It should be mentioned that I've had rough start issue as well about two times since I got the car.
I've found similar issue on Australian GT86 forums:
Quote:
|
The pinging occurs intermittently between 2000 to 3000rpm when you have no load on the throttle and apply throttle loading. I think it has happened a few times over 3000rpm for me. I've been able to replicate the ping in all gears besides first gear with anywhere of full load on the accelerator/throttle to even as low as 10% loading on the throttle with 5th gear being the easiest to replicate as your pretty much sitting in that rev range when your on the hume hwy at 70km/h.
|
Here is the link to the thread if anyone is interested: gt86 aussi forums /forum/f16/engine-pinging-rattle-noise-under-acceleration-953/
So has anyone else here experienced this issue and does anyone know what the hell this is?
I highly doubt this is a fuel pump issue as I have 0 crickets under my hood, but from the part order I saw the dealership put in that's the excuse they used.