|
Issues | Warranty | Recalls / TSB Problems, issues, recalls, TSBs |
|
Thread Tools | Search this Thread |
10-15-2019, 03:43 PM | #1 |
Senior Member
Join Date: Oct 2014
Drives: 2014 Monogram Hot Lava
Location: S.E. Pa
Posts: 111
Thanks: 1,507
Thanked 139 Times in 51 Posts
Mentioned: 3 Post(s)
Tagged: 1 Thread(s)
|
Suddenly, gas on ground while fueling!!
From the vent tube behind the right rear wheel. I figured the dreaded filler neck hose problem. Since it appears to take a bit to get really bad, I wasn't in a big hurry. Next fueling gas started coming out of the filler neck onto the forking paint!! Panic!!
Made an appoint at a repair place where one of the techs had owned an FRS... First inspected fuel filler neck and fuel hose per customer info and common issues found on the internet. So pulled filler neck hose and boroscoped hose to check for delamination or clogging. None found at this time. Smoke tested evap system to check for any major clogging and there was none found. There is some flow coming out of the canister vent tube. But smoke testing does not replicate the volume of air or fluid being moved by filling the vehicle with gasoline. So pull the hose off of the canister vent filter and blue through it with more air and it flows just fine. Blew back into the canister vent valve to check for flow there and there is a very restricted flow in that direction. Also sucked air through the canister vent valve to checked for flow in that direction and there was also a large restriction. While sucking air through that direction two stink bugs came out of the leak detection pump which the canister vent valve is located in. There seems to be some sort of large restriction inside the leak detection pump which maybe dirt or a stink bug infestation that is causing restricted airflow. Leak detection pump and evap canister would need to be removed to either clean out or replace. Both the EVAP canister and LDP are located above the rear subframe and the labor time for replacing them is 6.6 hours due to needing how to remove the rear subframe. Stink Bugs!?! I don't need no Steeken Stink Bugs!! Since it was late Friday there was no way to get parts or work done so I cruise home. I start cogitating... Get home, remove rear right wheel, yank away the housing, grab shop vac and slide vent tube into hose end, seal with tape, pop gas tank cap and let'er rip for a minute. Put everything back together, cruise to Ye Olde Filling Station, and fill up with No Problem!! Don't know if it's a permanent fix, but if I get a gas filling problem again, I try the vacuum hose approach before anything else.
__________________
It's all about gearing and steering.
|
The Following 3 Users Say Thank You to Hoahao For This Useful Post: |
10-15-2019, 05:48 PM | #2 |
Geo Tyrebighter Esq
Join Date: Mar 2013
Drives: '13 scion fr-s
Location: pnw
Posts: 4,182
Thanks: 6,313
Thanked 4,976 Times in 2,195 Posts
Mentioned: 39 Post(s)
Tagged: 1 Thread(s)
|
Might try some skeeter netting on the vent outlet where the bugs are getting it on.
__________________
--
"I gotta rock." -- Charley Brown |
The Following User Says Thank You to bcj For This Useful Post: | Hoahao (10-15-2019) |
10-15-2019, 06:56 PM | #3 |
Senior Member
Join Date: Oct 2014
Drives: 2014 Monogram Hot Lava
Location: S.E. Pa
Posts: 111
Thanks: 1,507
Thanked 139 Times in 51 Posts
Mentioned: 3 Post(s)
Tagged: 1 Thread(s)
|
Good idea.
__________________
It's all about gearing and steering.
|
10-15-2019, 09:41 PM | #4 |
Senior Member
Join Date: May 2013
Drives: 2013 FR-S, white, MT
Location: Puyallup, WA
Posts: 29,866
Thanks: 28,787
Thanked 31,813 Times in 16,424 Posts
Mentioned: 708 Post(s)
Tagged: 2 Thread(s)
|
sounds like a good Bubba fix to me.
humfrz |
The Following 2 Users Say Thank You to humfrz For This Useful Post: | Hoahao (10-17-2019), soundman98 (10-16-2019) |
|
|
Thread Tools | Search this Thread |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
Cruise control and current gear suddenly not working, but suddenly worked again | btan219 | Issues | Warranty | Recalls / TSB | 2 | 06-30-2018 01:09 AM |
When to upgrade fueling? | SirSpectre | Forced Induction | 5 | 10-06-2015 11:56 AM |
Transient Fueling ~ DI/PI | Kodename47 | Software Tuning | 2 | 07-17-2015 06:27 AM |
Fueling Issue | Simisimi | Issues | Warranty | Recalls / TSB | 5 | 12-22-2014 05:17 PM |
About to buy my BRZ then suddenly... | Mango22 | BRZ First-Gen (2012+) -- General Topics | 44 | 09-10-2012 10:04 AM |